日光温室热压风压耦合自然通风流量的模拟

doi:10.3969/j.issn.1000-6362.2016.05.005

摘要/Abstract

摘要：

通风是温室环境调节的重要手段，通风流量计算涉及流量系数与风压体型系数，因此有必要定量分析不同通风模式下的通风流量及对应的系数，为通风调节提供理论依据。本文分析了热压风压耦合作用对通风流量的影响机理，构建了通风流量与热压风压作用关系的数理模型；采用CO₂气体示踪法测试日光温室模型(按1:5的比例缩小)在不同通风口宽度条件下的通风流量，将试验测得的通风流量、空气温度、风速和通风口宽度等参数代入模型，对模拟值与实测值进行多元线性拟合，得出拟合度最高的流量系数与风压体型系数。结果表明：当温室模型通风口宽度为3、5和7cm（相当于实际温室通风口宽度为15、25、35cm）时，热压风压耦合作用的通风流量可按G=0.81S•（H•?T/T)^0.5 +0.078S•u、G=0.63S•（H•?T/T)^0.5 +0.067S•u 和 G=0.46S•（H•?T/T)^0.5 +0.058S•u分别计算，式中S、H、 ?T、T、u分别为通风口面积、宽度、室内外温差、室外温度和风速；相应的流量系数分别为0.78、0.60和0.44，风压体型系数分别为0.04、0.05和0.07；在总通风流量中，当室外风速高于1.5m·s^-1时，风压通风流量所占总通风流量的比例均高于50%，风压通风占主导作用；当室外风速大于2.5m·s^-1时，风压形成的通风流量所占比例均大于70%，说明此条件下可忽略温度即热压的影响。

关键词: 日光温室, 通风流量, 流量系数, 风压体型系数, 模拟

Abstract:

Natural ventilation is a key measure for greenhouse environment adjustment, and ventilation flux calculation involves the discharge coefficient and wind effect coefficient. So, it is necessary to analyze the air volume flux over different vent types and the corresponding coefficients. The effects mechanism of the coupling between the stack and wind effects on ventilation flux was analyzed, and a model of air exchange in a solar greenhouse was established considering two main driving forces of ventilation. The tracer gas technique using carbon dioxide was used in a scaled greenhouse (scale rateis 1:5) to identify the ventilation flux. From measurements of volumetric flow rates, climate parameters and opening width, the model parameters, the discharge coefficient and the wind effect coefficient were identified by fitting the experimental data to the model using multi-linear regression. The results showed that the ventilation flux could be calculated by the following equations,G=0.81S•（H•?T/T)^0.5 +0.078S•u，G=0.63S•（H•?T/T)^0.5 +0.067S•u and G=0.46S•（H•?T/T)^0.5 +0.058S•u , where S and H was opening area and opening width; ?T was the temperature difference between inside and outside; T and u was the outside air temperature and velocity. The identified values of the discharge coefficient were 0.78, 0.6, and 0.44, and the wind effect coefficients were 0.78, 0.6, 0.44 when the vent opening widths were 3cm, 5cm and 7cm, respectively (equal to the opening widths in an actual greenhouse 15cm, 25cm and 35cm). It was shown that the ventilation flux due to the wind effect over total ventilation flux was over 50% when the wind velocity exceeds 1.5m·s^-1 and that could be over 70% when the wind velocity exceeds 2.5m·s^-1, which indicated that the temperature or buoyancy effect could be neglected.

Key words: Chinese solar greenhouse, Ventilation flux, Discharge coefficient, Wind effect coefficient, Simulation

方慧，杨其长，张义，程瑞锋，张芳，卢威. 日光温室热压风压耦合自然通风流量的模拟[J]. 中国农业气象, 2016, 37(05): 531-537.

FANG Hui, YANG Qi-chang, ZHANG Yi, CHENG Rui-feng, ZHANG Fang, LU Wei. Simulation on Ventilation Flux of Solar Greenhouse Based on the Coupling between Stack and Wind Effects[J]. Chinese Journal of Agrometeorology, 2016, 37(05): 531-537.

参考文献

[1] 魏晓明,周长吉,曹楠,等.中国日光温室结构及性能的演变[J].江苏农业学报,2012,28(4):855-860. Wei X M,Zhou C J,Cao N,et al.Evolution of structure and performance of Chinese solar greenhouse[J].Jiangsu Academy Agriculture Sciences,2012,28(4):855-860.(in Chinese) [2] Mashonjowa E,Nhiwatiwa D,Ronsse F.Application of a tracer aerosol technique using atomised NaCl particles for measuring ventilation rates in a naturally ventilated Azrom type greenhouse in Zimbabwe[J].Appl. Eng.Agric,2010a, 26(2):275-286. [3] Mashonjowa E,Ronsse F,Milford J R,et al.Measurement and simulation of the ventilation rates in a naturally ventilated greenhouse in Zimbabwe[J].Appl.Eng.Agric,2010b,26(3): 475-488. [4] Mashonjowa E,Ronsse F,Milfor J R,et al.Modelling the thermal performance of a naturally ventilated greenhouse in Zimbabwe using a dynamic greenhouse climate model[J]. Solar Energy, 2013, 91:381-393. [5] 王健,丁为民,杨红兵.间隔互插式连栋温室的自然通风模拟与优化[J].计算机仿真,2006,(12):310-312. Wang J,Ding W M,Yang H B.Simulation and optimization of natural ventilation for mutual interval insert type multi-span greenhouse[J].Computer Simulation,2006,(12):310-312.(in Chinese) [6] 沈明卫,郝飞麟.连栋塑料温室自然通风流场的稳态模拟:顶窗配置形式对温室内流场的影响[J].浙江大学学报(工学版),2007,41(4):668-672. Shen M W,Hao F L.Steady simulation of airflow distribution of natural ventilation inside multi-span plastic greenhouse: effect of transom window configuration on airflow field inside greenhouse[J].Journal of Zhejiang University(Engineering Science),2007,41(4):668-672.(in Chinese) [7] 程秀花,毛罕平,伍德林,等.玻璃温室自然通风热环境时空分布数值模拟[J].农业机械学报,2009,40(6):179-183. Cheng X H,Mao H P,Wu D L,et al.Numerical simulation of thermal profiles in spatial and temporal field for natural ventilated glasshouse[J].Transactions of the Chinese Society for Agricultural Machinery,2009,40(6):179-183.(in Chinese) [8] 李永博,周伟,李鹏飞,等.基于CFD模拟模型的温室温度场均匀性控制[J].农业机械学报,2012,43(4):156-161. Li Y B,Zhou W,Li P F,et al.Temperature homogeneity control of greenhouse based on CFD simulation model[J]. Transactions of the Chinese Society for Agricultural Machinery, 2012,43(4):156-161.(in Chinese) [9] 李树海,马承伟,张俊芳,等.多层覆盖连栋温室热环境模型构建[J].农业工程学报,2004,20(3):217-221. Li S H,Ma C W,Zhang J F,et al.Thermal model of multi-span greenhouses with multi-layer covers[J].Transactions of the CSAE,2004,20(3):217-221.(in Chinese) [10] Boulard T,Baille B.Modelling of air exchange rate in a greenhouse equipped with continuous roof vents[J].J.Agric. Engng Res,1995,61:37-48. [11] Boulard T,Menenses J F,Mermier M,et al.The mechanisms involved in the natural ventilation of greenhouse[J]. Agricultural and Forest Meteorology,1997a,79:61. [12] Boulard T,Papadakis G,Kittas C,et al.Air flow and associated sensible heat exchange in a natural ventilated greenhouse[J]. Agricultural and Forest Meteorology,1997b, 88:111-119. [13] Papadakis G,Mermier M,Meneses J F,et al.Measurements analysis of air exchange rates in a greenhouse with continuous roof and side opening[J].Agric.Eng.Res, 1996,63: 219-227. [14] Katsoulas N,Bartzanas T,Boulard T.Effect of vent openings and insect screens on greenhouse ventilation[J].Biosystems Engineering,2006,93(4):334-350. [15] Fatnassi H,Boulard T,Bouirden L.Simulation of climatic conditions in full-scale greenhouse fitted with insect proof screens[J].Agric.And Forest Meteorol,2003,118(1-2):97-111. [16] Wang S X,Wang X.Ventilation rate of various vents in plastic covered multi-span greenhouse[J].Transactions of the CSAE,2009,25(11):248-252. [17] Fatnassi H,Boulard T,Bouirden L.Development, validation and use of a dynamic model for simulate the climate conditions in a large scale greenhouse equipped with insect-proof nets[J].Computers and Electronics in Agriculture,2013,98:54-61. [18] Bot G P A.Greenhouse climate:from physical processes to a dynamic model[D].Wageningen:Wageningen University, 1983. [19] Kozai T,Sasa S,Nara M.A modelling approach to greenhouse ventilation control[J].Acta Horticulturae,1980,106:125-136. [20] Brown W G,Solvason K R.Natural convection through rectangular openings in partition[J].International Journal of Heat and Mass Transfer,1963,5:859-868. [21] Kittas C,Boulard T,Mermier M,et al.Wind induced air exchange rates in a greenhouse tunnel with continuous side openings[J].J.Agric.Engng Res,1996,65:37-49. [22] Reichrath S,Davies T.Computational fluid dynamics simulations and validation of the pressure distribution on the roof of a commercial multi-span Venlo type glasshouse[J]. Wind Engineering and Industrial Aerodynamics, 2002a,90: 139-149.